[C320-list] Fw: Fw: stuffing box packing

[Jerry Clayton]

Dave,

Good idea, I have some onboard lying in the chart table.

Thanks,

Jerry
----- Original Message ----- 
From: "Dave Leon" <v-daleon at hotmail.com>
To: "C320-List" <c320-list at catalina320.com>
Sent: Tuesday, October 31, 2006 11:22 AM
Subject: Re: [C320-list] Fw: stuffing box packing


Jerry,
I used silicone rescue tape http://www.rescuetape.com/ to stop the water. 2 
wraps around the stuffing box and shaft. Sealed everything up tight. It 
sticks to itself so it is easy to remove when you are done.

Dave Leon



> From: jsea at prodigy.net> To: C320-List at catalina320.com> Date: Tue, 31 Oct 
> 2006 10:53:04 -0800> Subject: [C320-list] Fw: stuffing box packing> > 
> Bob,> > Did you do this with the boat in the water, or on the hard? I have 
>  > been wanting to do this, but haven't yet, do to concerns over 
> controlling > the water intake during the installation process. Any 
> suggestions anyone?> > Regards,> > Jerry Clayton> Tropo #988> -----  
> Original Message ----- > From: "Robert E. Sloat" <resloat at comcast.net>> 
> To: "C320-List" <c320-list at catalina320.com>> Sent: Tuesday, October 31, 
> 2006 6:20 AM> Subject: Re: [C320-list] stuffing box packing> > > >I have 
> hull 894 (2002) and the same situation with the owner's manual > >saying 
> 3/16 inch packing dimension. When measured using drills the packing > >was 
> 1/4 inch. I used the 1/4 inch Gortex packing from emarine mentioned in > 
>  >an earlier string and basically eliminated any leakage to the bilge. I > 
>  >readjust once or twice during the season. This is the best $15 investment 
>  > >made on the boat and it only takes about 20 boat minutes to replace the 
>  > >packing. The hardest part was getting the old packing out and cleaning 
>  > >packing off of the threads on the packing fitting so it could screw 
> tight.> >> > This is the 3rd season on the packing. On thing I noticed is 
> that I could > > only get 2 layers of packing in the fitting and the 
> instructions say use 3 > > layers. I think there were only 2 layers of the 
> original stuff in the > > fitting.> > Bob Sloat> > Savannah> > -----  
> Original Message ----- > > From: "Bill Culbertson" 
> <billculb_a2 at yahoo.com>> > To: <catalina at thehares.com>; "C320-List" 
> <c320-list at catalina320.com>> > Sent: Monday, October 30, 2006 10:10 PM> > 
> Subject: Re: [C320-list] stuffing box packing> >> >> > Bert,> >> > Jeff 
> describes my situation. My manual says 3/16" just like yours. But > > my 
> stuffing box takes 1/4".> >> > The dealer had put 1/4" when I took 
> delivery. It leaked by season end so > > when I replaced, I replaced with 
> 3/16" per the manual. When I changed > > that out after the 2nd season, I 
> could see that the rings had a > > rectangular cross-section - not square. 
> One dimension was about 1/4" - > > the other much skinnier than the 
> original 3/16".> >> > So I used the drill bit technique, found that 1/4" 
> drill bit fit fine and > > snugly, and switched back to 1/4".> >> > -bill> 
>  >> > ----- Original Message ----> > From: Jeffrey Hare 
> <catalina at thehares.com>> > To: C320-List <c320-list at catalina320.com>> > 
> Sent: Monday, October 30, 2006 6:55:33 PM> > Subject: Re: [C320-list] 
> stuffing box packing> >> >> > Bert,> >> > I believe most people have 
> reported that 1/4" is what actually fits on> > our boats, even though the 
> manual says 3/16". If you've actually used > > 3/16"> > and had it work, 
> then you're boat is seems to be an exception to the norm.> > :)> >> > Many 
> folks have switched over to GFO packing material for dripless> > 
> operation.> >> > -Jeff> >> > -----Original Message-----> > From: 
> BAdams3491 at aol.com [mailto:BAdams3491 at aol.com]> > Sent: Monday, October 
> 30, 2006 6:27 PM> > To: c320-list at catalina320.com> > Subject: Re: 
> [C320-list] stuffing box packing> >> > Don't know what people are saying, 
> but the owner's manual for my 1997 > > model> > says 3/16".> >> > Bert> > 
> At Ease> > #442> >> >> > > >
_________________________________________________________________
Call friends with PC-to-PC calling -- FREE
http://get.live.com/messenger/overview=