[C320-list] Water in fuel

[Jane & Ken]

Lew,  that is a statement you will never hear from a power boat polluter.  Ken

--- On Tue, 7/31/12, sailorlew at aol.com <sailorlew at aol.com> wrote:


From: sailorlew at aol.com <sailorlew at aol.com>
Subject: Re: [C320-list] Water in fuel
To: C320-List at Catalina320.com
Date: Tuesday, July 31, 2012, 4:26 PM


Since I only put in fuel once a year, after doing so I put a bead of rope caulking around the cap as a 2nd source of a water seal.
Lew



-----Original Message-----
From: Warren Updike <wupdike at hotmail.com>
To: C320-List <C320-List at Catalina320.com>
Sent: Tue, Jul 31, 2012 8:50 am
Subject: Re: [C320-list] Water in fuel


Also a good idea to replace the "O" ring in the fuel filler cap every couple
of years.  Without a tight seal at the cap, rain water can find its way into
the tank.

-----Original Message-----
From: Lee, Cliff [mailto:CLee at kbcat.com] 
Sent: Monday, June 25, 2012 5:06 PM
To: c320-list at lists.catalina320.com
Subject: [C320-list] Water in fuel

We inadvertently sprayed water up into the fuel vent connection last fall
when hosing down the boat.  When we started the engine up the next weekend,
she started and then stalled out within a couple of minutes (luckily still
at the dock).  I noticed water in the fuel/water separator, so took the long
overdue opportunity to replace the separator but afterward noticed I was
continuing to collect water in the separator plastic bulb.  I went through
the tedious but simple process of draining water from the bleed drain for
2-3 hours (keep the fuel tank valve open) and finally got a clear pink
supply of diesel, after which the engine fired up no problem.  This spring I
noticed more water in the separator, but after a few drainings and a few
sailing outings the water has disappeared.  Anyway, we now only hose down
from above to avoid water in the fuel tank.  It sounds like your problem may
be more severe than that, but I figured I would confess to our "oops" moment
just in case.

Cliff Lee
Comfort Zone, #268

------Original Message --------
Date: Mon, 25 Jun 2012 11:25:42 -0400
From: Marko Jamnik <mjamnik at markocreative.net>
To: C320-List at Catalina320.com
Subject: [C320-list] Water in fuel
Message-ID: <51BC0450-C452-4929-8DAD-288B17AE0D01 at markocreative.net>
Content-Type: text/plain; charset=us-ascii

Into my third sailing season with my 1995 - 320. Boat came from brackish
waters to fresh water.  I had the motor taken out and had the  motor mounts
replaced as well as reconditioning the engine, all of the hoses filters
primary & secondary filters, zinc nodes impeller etc.  after all that it was
tested and the result the engine was in A1 condition. The last two seasons
no problems until now.  It's a Westerbeke 30B with a total of 1000 hrs.

I tried starting the engine this week and after two minutes the engine
stalled. I cranked it a number of times and no luck. The fuel gauge was
full. I had a mechanic look at it only to tell me that I was pumping through
water, out of the injectors that all I saw. The plan is to clean out the
tank and replace it with cleaner fuel. I think it was a matter of time that
the balance of water levelled with the fuel and with some sloshing around I
reached that cutoff point. Now my concern is that this will be a costly fix
especially since I have water in the system now. Concern of mine is that a
complete removal of water has to happen, I can't afford water in the
cylinders since it won't burn and once the fuel does kick in it can blow a
seals. The mystery here is how much water is in the system already 


I have checked the O ring and it's not cracked I still have to check the
vent fitting but this will be after the fact.

Before I hand over my retirement fund, just kidding. I'm wondering if anyone
else has had a similar experience.

If only it could run on water?

Mark

#304 
----------------------------------------------------------------------------
-----------------------------------------------------------
This e-mail is confidential and intended only for the individual(s) to whom
it is addressed. If you or your organisation is not an intended recipient of
this e-mail, please notify the sender by replying and do not read or
disseminate its information. Please delete all copies from your system. KBC
is liable neither for the proper or complete transmission of the information
contained in this communication nor for any delay in its receipt. Opinions,
conclusions and other information in this message and attachments that do
not relate to the official business of KBC are neither given nor endorsed by
it. Even though the Mimecast Virus Centre has checked this message for all
known viruses, you should carry out your own virus checks before opening any
attachments. Thank you for your co-operation.
www.kbcat.com---------------------------------------------------------------
--------------------------------------------------------------------------