[C320-list] Spares List

[ART HARDEN]

I cut off the bottom of a 1 gallon jug about 3 inches high to just fit underneath the stuffing box. It serves two purposes one it gives me an idea of the rate and which the stuffing box leaks, and it also catches the water before getting into the bilge. Generally, I do not get enough to overflow the pan and just pump it out before the next trip out. The stuffing box is usually tightened enough that it does not drip when stationary, but does lubricate shaft when running. also I have a feathering prop so that eliminates the rotation while Sailing.

Sent from my iPhone
Art Harden
Catalina 320 "Tortuga" E-62
937.885.9380 (o)
937.477.5544 (m)

> On Jul 19, 2024, at 4:46 PM, Bob Borelli via C320-list <c320-list at lists.catalina320.com> wrote:
> 
> PAR Handy Boy brass hand pump.
> With clear red reinforced hose clamped to both ends
> with 12" of 1/2' copper tubing clamped to the hose at either end.
> 
> this way I can hand pump bilge water from under the holding tank or
> under the galley sink cabinet into the galley sink drain.
> And from the upper bilge pan.
> 
> That water that seeps in while operating the propellor shaft stuffing box
> goes into the bilge.
> 
> Bob Borelli C320 no. 209
> ________________________________
> From: C320-list <c320-list-bounces at lists.catalina320.com> on behalf of Bob Borelli via C320-list <c320-list at lists.catalina320.com>
> Sent: Friday, July 19, 2024 4:22 PM
> To: C320-List at Catalina320.com <C320-List at Catalina320.com>
> Cc: Bob Borelli <cassattc22 at hotmail.com>
> Subject: Re: [C320-list] Spares List
> 
> I keep on my boat:
> (2) Primary & (2) Secondary fuel filters.
> Instruction on to change & bleed fuel system.
> Wrenches required / small funnel / empty plastic bottle.
> Clamp wrench to remove Racor filter.
> Awl & ball peen hammer in case wrench does not remove filter.
> White pig towels that only absorb fuel & oil.
> Spray Nine Marine cleaner / Blue Shop towels / Plastic gloves / Plastic trash bags.
> 
> (4) small bright flashlights.
> (2) raw water pump impellers / long nose plier to pull out / gasket / socket to remove cover /Lube to coat new impeller.
> Fan belt & wrenches to move alternator.
> WD-40 small can.
> 
> Multi-meter!  /  First Aid Kit!  /  Log Book  /  Kroil spray /  Sailing gloves.
> 
> I minimize what I keep onboard, only what I need, store in out of way, sounds like alot, but not:
> Tool box / Ratchet & wrench box / 12 volt tool box / multi-compartment screws, nuts, bolts / pipe tool box
> 5/8" reinforced tube slide over 15MM tubing with clamps.
> Wood bungs / (2) inflatable PFD re-arm kits / extra start keys / Heavy needle & thread
> 
> Basic tools essential like screw drivers, utility knife with extra blades, hack saw blade.
> Generally, only keep onboard what I learn to need for sailing, cruising.
> I met a sailor once had a sailing hardware store.  I keep in mind I want to sail this boat, keep it clear, but keep what's needed.
> What do you need extra shackles for?  Got extra short Phillips screw driver to open mast gate?
> Extra mast gate screws.  Got gloves to pull anchor rode?  Sailkote for main sail lugs?  Tools fall overboard easily.
> Tie wraps / 2' & 4' lengths of rope ready for use.
> Small bottle motor oil, Prestone 50/50, gearbox lube.
> Clear Gorilla tape / electric tape.
> 
> I should prepare inventory.  Don't' need it, don't keep it onboard.
> I completed an inventory list of my safety equipment.
> I sail alone.  But when I do have company I point what & where safety items.
> 
> Inventory list for tool onboard a good idea!  thank you!
> 
> 
> Bob Borelli   1995 C320 no. 209  'Elusive' Perkins M30 moored on the Sassafras.
> 
> 
> ________________________________
> From: C320-list <c320-list-bounces at lists.catalina320.com> on behalf of Brian McLamb via C320-list <c320-list at lists.catalina320.com>
> Sent: Friday, July 19, 2024 12:21 PM
> To: C320-List at catalina320.com <C320-List at catalina320.com>
> Cc: Brian McLamb <bjcnmclamb at gmail.com>
> Subject: Re: [C320-list] Spares List
> 
> Depends upon your engine. I have a Yanmar and they sell an emergency kit
> for my engine. It includes belts filters (oil and diesel) and impeller.
> Each spring I remove old from engine and insert from emergency kit. Then
> replenish the emergency kit with any part used. This means my spares are
> new and old 1 year old
> S/V Serenity #1075
> 
> 
> Brian McLamb
> 
> 
>> On Fri, Jul 19, 2024 at 10:59 AM Christian via C320-list <
>> c320-list at lists.catalina320.com> wrote:
>> 
>> Comment on impeller and belt spare.  My opinion is that impellers should be
>> changed at regular intervals (1-2 years, depending on your risk
>> acceptance), and if changed regularly, spare impeller should not be
>> needed.  Aslo the rubber on the impeller does age, so your spare could
>> become a risk for torn fins clogging your system if used and it's old.  Age
>> is also a factor for belts.  But I do think a spare belt should be
>> onboard.  What I do is change my belt every 2 years, and keep the old one
>> as my spare.  Should I ever need to fall back on my spare belt in open
>> water, it would be replaced as soon as I can with a fresh belt.
>> 
>> Another important tool I recommend carrying is 2 adjustable slim wrenches
>> for tightening the nut on your stuffing box.
>> Christian 1994 C320 #138 "Canuck" Monroe Harbor, Chicago, IL
>> 
>> On Fri, Jul 19, 2024 at 9:48 AM Tim Van de Water via C320-list <
>> c320-list at lists.catalina320.com> wrote:
>> 
>>> I have appreciated the recent thread on the tools you carry.  As a
>>> relatively new C-320 owner (acquired Coda #537 last August), I would
>>> appreciate a list of the spares you carry.  I've got an impeller spare, a
>>> belt for the water pump/alternator, some light bulbs, some cotter pins,
>> and
>>> a handful of shackles/rigging spares.
>>> 
>>> What are you carrying and how/where are you storing it?
>>> 
>>> Regards,
>>> 
>>> 
>>> *Tim Van de Water*SV Coda #537
>>> 404.790.2208
>>> tj.vandewater at gmail.com
>>> 
>>