[C320-list] Whale Fittings
Paul Rickman
ilove2sail at verizon.net
Thu Aug 27 06:42:19 PDT 2009
In this same area, just off that short hose and quick connect fitting is a short backflow preventer (Whale) that
then fits into another quick connect fitting, both Whale. I've replaced the two quick connect fittings
but not the back flow prevener which is the same diameter as the reqular water line. Just at the end of a two day cruise, the back flow preventer blew out of the "T" connector. This is the third time this has happened. Apparently Whale has changed the back flow, it is shorter and just won't work with my set up. Have any
of you had this experience and do you have a solution for it? Do you think extending the length of hose
would be a good fix? (to get it away from the heat) I've tried working with the West Marine Store in Annapolis just off Forrest Drive, but most of the Whale fittings there are in a box marked "quick connect"
sitting on a high shelf and no on display. They don't really seem interested in working with the customer on
this sort of problem.
IMHO the heat here may have something to do with the blow out. But it has worked for many years.
My experience is the same with the newer fittings, no cap, no C spacer.
Thanks,
Paul
Affinity 657
Bay Bridge Marina
________________________________
From: Robert Seastream <robert.seastream at comcast.net>
To: C320-List at Catalina320.com
Sent: Monday, August 24, 2009 7:04:01 PM
Subject: Re: [C320-list] Whale Fittings
BTW, right at the start of this summers 2 week 'mini cruise' to Maine, I had to replace the short (2 inch?) piece of hose at the hot water heater you mention. Goodness knows why Catalina used such a short length. Interesting chore while underway. THIS time, I replaced it with a 6 inch length of hose (keeping another 6 inch piece as spare), figuring if either end leaked again, I'd have room to cut the bad section away without replacing the whole run. It also made working with the overall assembly easier.
Bob Seastream
Intuition # 906
On Aug 24, 2009, at 11:36 AM, BAdams3491 at aol.com wrote:
> Dave,
>
> Thanks for the tip. Yesterday I did what you suggested...in fact I left
> the cap off since it really does not do anything. Worked great.
>
> Bert
> At Ease
> #442
>
>
> In a message dated 8/18/2009 8:27:45 P.M. Central Daylight Time,
> djgleason1 at juno.com writes:
>
> Bert:
>
> I have experienced a similar problem with one of the fittings. The cap
> is there to keep the "C" spacer in place so that it does not come off
> accidently. What I have done is to break the cap to remove the C spacer.
> When I reinstalled the fitting, I simply wrapped a piece of tape around
> the fitting to keep the "C" spacer in place. I note that the replacement
> fittings I have used no longer use the Cap or the "C" spacer.
>
> Dave Gleason
> Proud Mary, #150
>
>
> On Sun, 16 Aug 2009 12:40:12 EDT BAdams3491 at aol.com writes:
>> I have the standard 15mm Whale fittings on my fresh water system.
>> They
>> all come apart as they should except the two 90 degree fittings
>> that go into
>> the hot water heater. The connection away from the heater pops off
>> as
>> normal with the cap that secures it sliding away from the
>> connection. However
>> the side that connects to the water heater will not come off...hot
>> and cold
>> same problem. The cap will not 'pop' off. When I try to pop it
>> off with
>> a small screw driver, it will come partially off at that one point,
>> but
>> that's all. It's off far enough so the cap that should come off is
>> tight
>> enough so that it cannot be turned so I can get at the other
>> opening on the
>> opposite side to try to get it off. The other problem is that the
>> fitting is
>> so close to the heater that there is not enough room for the cap to
>> slide
>> back ...which appears to be why it won't pop off in the first
>> place.
>>
>> Any suggestions certainly appreciated. Thanks.
>>
>> Bert
>> At Ease
>> #442
>>
>
> ____________________________________________________________
> Need cash? Click to get a loan.
> http://thirdpartyoffers.juno.com/TGL2141/fc/BLSrjpTFRc814aEDMd4J0WbcBCeJFRL3
> 013JojCjsqKwZLvt2cbW8mSkTza/
>
>
More information about the C320-list
mailing list