[C320-list] Fwd: Mysterious water leak C320 Hull 78

[Sam]

Mine was ok, but he did check mine since he noticed other Cat' s with this problem. Sam

Sent from my iPhone

On Oct 3, 2012, at 11:23 AM, Jeff Brown <oceanblues at mac.com> wrote:

> Sam,
> Thanks for the note, that's what I was afraid of.  I've narrowed it down to this particular problem and the most likely culprit, tried everything else that others have pointed out.  But since it is glassed over, it appears to be a big project.  Did you have yours fixed or did your mechanic just point this out?
> 
> Best regards,
> 
> Jeffrey Brown
> (949) 350-5123
> 
> 
> 
> 
> On Oct 3, 2012, at 8:44 AM, Sam wrote:
> 
>> I had my boat pulled recently and the marina mechanic stated he has noticed problems with Catalina shaft stuts. Sam
>> 
>> Sent from my iPhone
>> 
>> Begin forwarded message:
>> 
>>> From: "Dennis Harris" <dharris02 at suddenlink.net>
>>> Date: October 2, 2012, 4:39:00 PM CDT
>>> To: <C320-List at Catalina320.com>
>>> Subject: Re: [C320-list] Mysterious water leak C320 Hull 78
>>> Reply-To: C320-List at Catalina320.com
>>> 
>>> An additional thing to check is the cutless bearing/shaft stut.  It bolts through the hull with four bolts.  As I recall, this area has glass over it on most boats, but some may not have been covered.  Also, vibration over time might have opened up this area.
>>> 
>>> Dennis Harris C-320 #694
>>> 
>>> -----Original Message----- From: Dean Vermeire
>>> Sent: Tuesday, October 02, 2012 5:09 PM
>>> To: C320-List at Catalina320.com
>>> Subject: Re: [C320-list] Mysterious water leak C320 Hull 78
>>> 
>>> Hi Jeff,
>>> 
>>> Just a thought, but I would dry everything out as best as I could, and
>>> then put newspaper down everywhere I could get to inside. Wait a while
>>> and then look to see where it is wet.
>>> 
>>> Dean Vermeire
>>> #847
>>> 
>>> On 10/2/2012 3:42 PM, Jeff Brown wrote:
>>>> Hi C320 Group:
>>>> Our C320 is located in the marina of Dana Point, California.  So I've been battling a mysterious water leak (not fresh water so it's not coming from top or fresh water tanks).  We're taking on about 2 gallons of water per day, so it's significant.  So here's what I've checked:
>>>> 
>>>> 1. All through holes are dry and not leaking, closed all of them and leak continued
>>>> 2. Checked under floor boards, no leaks from any of the bolts that hold the keel to the bottom
>>>> 3. Checked depth gauge and knot meter fittings, no leaks
>>>> 4. Replaced packing gland with "dripless" packing and its not coming from here
>>>> 5. I've opened every floorboard, took everything out of cabinets and darn near torn open the whole boat, no detection of water entry.
>>>> 
>>>> So, my analysis of the general area of the leak, at least what I am able to see, it's coming from somewhere on the bottom of the boat from the bilge pump back to somewhere under the engine.
>>>> 
>>>> There are two areas I am unable to visibly see.  The space under the kitchenette floor back to under the engine, there is a space but it's not accessible.  I've called several boat mechanics, explained the problem and can't find anyone who thinks they can figure it out.  Called Catalina, Kent in California and Kurt in Florida, and they are as stumped as I.
>>>> 
>>>> So, if anyone has had a similar experience, please let me know. If you haven't had the same issue but can provide guidance on how we would go about finding the problem (i.e haul it out and look for cracks) or any help, it's greatly appreciated.  As you can imagine, everyday I fear going to the boat and finding it under water.
>>>> 
>>>> 
>>>> Best regards,
>>>> 
>>>> Jeffrey Brown
>>>> (949) 350-5123
>>>> 
>>>> 
>>>> 
>>>> 
>>>> 
>>>> 
>>> 
>