[C320-list] Locating new thru-hull for A/C

[Wash, Steve]

Hi Warren,
One of our friends has hull #93.  When he put in the A/C, they located the thru hull and pump under the drawers (under the sink).   The A/C unit is located in the port locker in the cockpit.  They located the discharge in the port side ... They have had some issues where the pump would not always prime.  The length of hose from the thru hull to the pump is very short (24").  If they get a bubble in the line (from bumpy water) there is not enough water to keep the pump primed and overcome the head to push the water to the discharge (which is above the pump about 12").

On my boat (#1029) we located the thru hull near the thru hull for the engine.  Our pump is under the aft berth and the discharge is thru the stern below the swim deck.  We have never had priming problems.

On hull #93, they were able to route the hose under the floor and back to the locker.

I hope this helps.  

Steve
#1029



-----Original Message-----
From: c320-list-bounces at lists.catalina320.com [mailto:c320-list-bounces at lists.catalina320.com] On Behalf Of Warren Updike
Sent: Monday, February 04, 2013 3:42 PM
To: C320-List at Catalina320.com
Subject: Re: [C320-list] Locating new thru-hull for A/C

Thanks, Ken.  I, too, have an available thru-hull as we don't flush with sea water.  I'm wondering how you routed the hose back to the A/C.  That's the mystery I can't solve.  

Warren & Pattie Updike
1994 C320 #62 "Warr De Mar"

-----Original Message-----
From: Jane & Ken [mailto:obuoy4848 at sbcglobal.net]
Sent: Monday, February 04, 2013 12:56 PM
To: C320-List at Catalina320.com
Subject: Re: [C320-list] Locating new thru-hull for A/C

Warren,  On my former hull #219 I used the existing hole that fed the head. I placed a  Tee on the thru hull and ran the hose to a cut-off then to the a/c.  Worked fine for the reverse cycle heat/air unit.  I installed the compressor in the starboard lazzerett.  Ken

--- On Mon, 2/4/13, Warren Updike <wupdike at hotmail.com> wrote:

From: Warren Updike <wupdike at hotmail.com>
Subject: [C320-list] Locating new thru-hull for A/C
To: C320-List at Catalina320.com
Date: Monday, February 4, 2013, 11:43 AM

I'd like to hear from anyone with a '93-'95 hull about locating a new thru-hull for A/C in the shaft alley and the strainer/scoop you may have used on the hull.

 

The alley in these older models don't have near the room the later models have.  However, I'd like to not clutter up the area by the packing nut as it is already a b(*&^ to drain the primary fuel filter.  A typical boat conundrum.  

 

Warren Updike

Towson, MD

410-821-8246